Next Article in Journal
Novel Soil Bacterium Strain Desulfitobacterium sp. PGC-3-9 Detoxifies Trichothecene Mycotoxins in Wheat via De-Epoxidation under Aerobic and Anaerobic Conditions
Next Article in Special Issue
A Non-Enzyme and Non-Label Sensitive Fluorescent Aptasensor Based on Simulation-Assisted and Target-Triggered Hairpin Probe Self-Assembly for Ochratoxin a Detection
Previous Article in Journal
Endothelial Damage, Inflammation and Immunity in Chronic Kidney Disease
Previous Article in Special Issue
Sensitive Aflatoxin B1 Detection Using Nanoparticle-Based Competitive Magnetic Immunodetection
 
 
Font Type:
Arial Georgia Verdana
Font Size:
Aa Aa Aa
Line Spacing:
Column Width:
Background:
Article

Simultaneous Determination of Deoxynivalenol, Its Modified Forms, Nivalenol and Fusarenone-X in Feedstuffs by the Liquid Chromatography–Tandem Mass Spectrometry Method

Department of Pharmacology and Toxicology, National Veterinary Research Institute, Al. Partyzantów 57, 24-100 Puławy, Poland
*
Author to whom correspondence should be addressed.
Submission received: 27 April 2020 / Revised: 26 May 2020 / Accepted: 29 May 2020 / Published: 1 June 2020
(This article belongs to the Special Issue Rapid Detection of Mycotoxin Contamination)

Abstract

:
A liquid chromatography-tandem mass spectrometry method was developed for simultaneous determination of deoxynivalenol (DON), 3-acetyldeoxynivalenol (3Ac-DON), 15-acetyldeoxynivalenol (15Ac-DON), DON-3-glucoside (DON-3Glc) nivalenol and fusarenone-X in feedstuffs. Different techniques of sample preparation were tested: solid-liquid-extraction, QuEChERS, solid phase extraction with OASIS HLB columns or immunoaffinity columns and a Mycosep 225 Trich column. None of the six immunoaffinity columns tested showed cross-reactivity to all of the mycotoxins. Surprisingly, the results show that if the immunoaffinity columns bound 3Ac-DON, then they did not bind 15Ac-DON. The most efficient sample preparation was achieved with a Mycosep 225 Trich column clean-up. The chromatography was optimised to obtain full separation of all analytes (including 3Ac-DON and 15Ac-DON isomeric form). The validation results show the relative standard deviations for repeatability and reproducibility varied from 4% to 24%. The apparent recovery ranged between 92% and 97%, and the limit of quantification described a 1.30 to 50 µg/kg range. The method trueness was satisfactory, as assessed by a proficiency test and analysis of reference material. A total of 99 feed samples were analysed by the developed method, revealing the presence of DON and DON-3Glc in 85% and 86% of examined animal feeds, respectively at concentrations between 1.70 and 1709 µg/kg. The ratios DON-3Glc to DON in the surveyed feedstuffs were from a low of 3% to high of 59%.
Key Contribution: Full separation of all compounds was obtained including the isomeric forms. 13C-labeled internal standards were used. The proficiency of the method was successfully demonstrated.

1. Introduction

Type B trichothecenes are a group of mycotoxins produced by Fusarium genera (F. graminearum and F. culmorum) and are currently some of the most prevalent and important contaminants of cereals in the field. So far, the best-known toxins in feedstuffs in this group are deoxynivalenol (DON), nivalenol (NIV) and fusarenone-X (FUS-X) [1]. These toxins are resistant to milling, processing and heat and, therefore, it is very hard to eliminate them from the feed chain [2]. Among type B trichothecenes, DON is the most prevalent and hazardous mycotoxin and its occurrence can cause many adverse health effects in animals, such as feed refusal, emesis, suboptimal weight gain and diarrhoea, which can lead to economic losses. All animal species evaluated to date are susceptible to DON in this order of vulnerability: pigs > mice > rats > poultry ≈ ruminants [3].
Moreover, in recent years, the occurrence of so-called “modified mycotoxins” is an increasing concern in feed and food safety, since they remain undetected in testing for their parent mycotoxin [4]. Modified forms of DON can be formed by fungi as the acetylated derivatives: 3-acetyldeoxynivalenol (3Ac-DON) and 15-acetyldeoxynivalenol (15Ac-DON) or as a form of the parent toxins conjugated with glucose (DON-3glucoside; DON-3Glc). DON-3Glc is produced as part of the defense system of a plant infected by toxigenic fungi. These toxic compounds can transform into their parent toxin by hydrolysis in the mammalian digestive system [5]. DON-3Glc has lower toxicity than its precursor, while both acetylated forms possess equivalent or much stronger toxicity to animals, and their conversion into their native form also cannot be excluded [6]. Moreover, recently published papers show that 15Ac-DON has a higher toxicity then 3Ac-DON [7].
At the time of writing, the guidance values for the native form of DON in feedstuffs are set down in Commission Recommendation 2006/576/EC with amending Recommendation 2016/1319 [8,9], but other toxins (DON-3Glc, 3Ac-DON, 15Ac-DON, NIV and FUS-X) are not included. Consequently, the occurrence of DON modified forms would imply an underestimation of the level of DON contamination in feedstuffs. Nevertheless, in recent guidelines the European Food Safety Authority (EFSA) has launched calls for data on occurrence in food and feed of DON, NIV and modified DON mycotoxins to enable drafting of a scientific opinion on mycotoxins with respect to food and feed safety [10,11,12].
The important issue is the simultaneous determination of DON and its modified forms. Various methods for their analysis in cereals and feedstuffs have been reported, such as liquid chromatography (LC) coupled with tandem mass spectrometry (MS/MS) [13,14,15,16], fluorescence detection (FLD) [17], photodiode-array detection (PDA) [18,19,20], and ultra-high-performance supercritical fluid chromatography-tandem mass spectrometry (UHPSFC-MS/MS) [21]. Moreover, in recent years the introduction of high-resolution mass spectrometers (HRMS) has allowed screening of non-target compounds, novel compound identification and retrospective data analysis [22]. In previously published studies for chromatographic separation, authors used mostly C18 columns [13,16,19,23].
Different sample preparation techniques and clean-up approaches have been used in feedstuffs: solid-liquid-extraction (SLE) without clean-up [16,23], the quick, easy, cheap, effective, rugged and safe (QuEChERS) technique [24], solid-phase-extraction (SPE) [14] and immunoaffinity columns (IAC) [17,25,26]. While SLE is frequently applied for multi-mycotoxin analysis in feedstuffs, the inclusion of clean-up strategies in the procedure could increase the sensitivity of the method, as well as decrease high matrix effect for the difficult matrix.
One of the challenges in this analysis is the chromatographic separation of the 3Ac-DON and 15Ac-DON isomers, which only differ in structure by the position of the acetyl group. They have the same daughter ions, so it is crucial to fully separate them by LC-MS/MS for accurate quantification. Therefore it is important to derive validated methods for accurate assessment of exposure to DON and its metabolites by determining their levels in feedstuffs (due to their different toxicities).
The paper describes the development of a method for determination of DON, its modified forms, NIV and FUS-X with particular reference to the following aspects: full separation of all analytes (including isomeric forms of acetylated DON), comparison of different strategies for sample preparation and clean-up (SLE, QuEChERS, SPE with OASIS HLB columns or IACs and a Mycosep 225 Trich column) as well as verification of the method in a proficiency test (PT) and with naturally contaminated feed samples.

2. Results and Discussion

2.1. LC-MS/MS Optimisation

The optimisation of LC-MS/MS parameters was accomplished by directly applying tuning solutions of the selected mycotoxins at concentrations of 1 µg/mL each, using 0.1% CH3COOH and MeOH as a mobile phase. The MRM mode was used and the analytes were ionized in both positive (ESI+) and negative modes (ESI) (Table S1). In the case of positional isomers, proper quantification of 3Ac-DON and 15Ac-DON cannot be achieved through the difference of the product ion in MRM mode. In positive mode (339 m/z) the most abundant parent ion was the same for both analytes, but different product ions were chosen (339/231.2 and 339/279.1 for 3Ac-DON and 339/321.2 and 339/261.2 for 15Ac-DON) [27,28]. However, other studies show higher ionisation in positive mode with NH4+ adducts for 3Ac-DON and 15-AcDON [13,23] or in negative modes [14,16]. If two different daughter ions for both isomeric forms are be chosen, positive false results could sometimes occur. For proper qualification and quantification it is therefore essential to have successful baseline separation of analytes.

2.2. Chromatographic Separation

Due to the different polarities of the analysed toxins, several chromatographic columns (Table S2) and mobile phases were tested. Based on the literature data, hydrophilic interaction liquid chromatography (HILIC) was tested as a first choice. Satisfactory separation on DON and DON-3Glc was achieved with Luna HILIC column (Phenomenex, Torrance, CA, USA), For other toxins no satisfactory retention times were obtained, and poor separation of all analytes was observed (Figure 1A). Kinetex C18 and Kinetex Biphenyl columns (Phenomenex) were also compared (Figure 1B,C). Although, these columns enable DON, DON-3Glc, NIV and FUS-X to be separated, 3Ac- and 15Ac-DON were not. In our study, the best results were achieved using a Luna Omega Polar C18 column (Phenomenex; 100 × 2.1; 1.6 µm) which is designed for polar compounds. Application of this column with MeOH as the organic mobile phase allowed all analytes to be separated except 3Ac and 15Ac-DON, their peaks still broadening (Figure 2A), and co-eluted.
To obtain full separation of peaks, ACN was used as an organic mobile phase with specific gradient mode (2–6 min with an almost isocratic gradient from 15–18% of ACN) (Figure 2B). Moreover, the choice of ACN shortened retention time for all analytes, as well as the time of analysis. To date a lot of studies have described the chromatographic separation of DON, its modified mycotoxins, and other type B Trichothecenes in different biological matrixes [13,14,16,18,27,28,29,30,31,32,33,34]. Nevertheless, most of the authors did not achieve baseline separation of acetylated forms of DON. Only a few studies described the full chromatographic separation of these compounds [17,35,36]. Yoshinari et al. (2013) obtained retention times for 3Ac-DON and 15Ac-DON of 5.48 and 5.60 min, respectively. In a different study Goncalves et al. [17] achieved partial separation of the isomeric form (both peaks co-eluted). Contrary results were demonstrated by Slododchikova et al. [37] who concluded that the best for separation of the isomeric forms of acetylated DON was a pentafluorophenyl column and MeOH as the mobile phase.
In conclusion, the usage of a Phenomenex Luna Omega Polar C18 column (100 × 2.1; 1.6 µm) column with the combination of 0.2% CH3COOH with ACN as the mobile phase in a specific gradient mode achieves full separation of all tested compounds with a total run time of 12 min (Figure 2B).

2.3. Sample Preparation

2.3.1. IAC Testing

Six commercially available IACs were tested (DONTest, DZT MS-PREP, DON PREP, B-TeZ IAC, DONStar, and DONaok). Cross reactivity with the modified mycotoxins depended on the immobilized antibody [38]. While all the IACs showed excellent recovery for DON (Figure 3), none of them bound all DON metabolites and other toxins. For DON-3Glc, DONTEST, DZT MS-PREP, DON PREP and DONaok cross-reacted which is in line with other researchers’ results [17,20,39]. Contrary to findings in other papers, none of IACs tested retained 3Ac-DON and 15Ac-DON simultaneously. Our results showed that if the antibodies bound 3Ac-DON, they did not bind 15Ac-DON. These results are in disagreement with those of another study, where a DONTEST column was used to determine DON derivatives with good recoveries (over 80%), although with HPLC post-column derivatisation and fluorescence detection [17]. In turn, Versilovskis et al. [39] demonstrated that DZT MS-PREP, DONPREP and DONaok cross-reacted with 15Ac-DON, although the recoveries obtained were low, and did not exceed 25%. However, the chromatographic method did not separate 3Ac- and 15Ac-DON and the LC-MS/MS method was based on the MRM of the [M+H+] ions for both isomers, which can lead to false positive results. Lack of fully separated analytes could be a reason why other authors achieved discrepancy results. Moreover, we also checked possible cross-reactivity IACs with others B-trichothecene: NIV and FUS-X. From all tested IACs DONTEST, DONSTAR and B-TEZ bound NIV. Our results are in agreement with Uhlig et al. [40] where the authors highlighted that DONTEST retained NIV. For FUS-X, only DONTEST IAC bound toxins (25%), which was not tested in any previous papers. Because the DONTEST IAC showed best results of all the tested columns (but not full satisfactory), it was chosen for further evaluation.

2.3.2. Comparison of Different Strategies for Sample Preparation and Clean-Up

The suitability for extraction and clean-up of DONTEST IAC, OASIS HLB and Mycosep 225 was tested by using them according to the manufacturer’s instruction. The QuEChERS technique and SLE were prepared based on our previous experience [41,42]. As is shown in Figure 4 the best results were obtained for Mycosep 225 columns which are dedicated products for Trichothecene analysis. In our study, obtained ER were in the range of 86–94%, except for DON-3Glc where 30% recovery was achieved. However, application of matrix-matched calibration curves could effectively compensate for recovery losses (see the Method Validation section) [43]. Lower recovery of DON-3Glc using a Mycosep 225 column was previously reported [30].
A significant advantage of these columns was the lowest ME for all compounds (71–120%). “Push-through” columns were previously used with grain extracts [30], where the authors reported recovery for NIV, DON and FUS-X in the range of 75–85%. DONTEST IAC and SPE OASIS HLB cartridges were not suitable for the current study, because no recovery was observed by the former of 15Ac-DON or by the latter of FUS-X. QuEChERS and SLE show high ion suppression, e.g., 34% with DON-3Glc and 46% with 15Ac-DON, respectively. Consequently, the final procedure included clean-up with Mycosep 225 columns. Compared to other authors [15,39] the showed method allows for determination wider range of B-trichotecenes e.g., 15Ac-DON, NIV or FUS-X. Moreover, application for clean-up of sample Mycosep 225 is not as expensive as selective clean-up with IAC, which is frequently used for determination of DON and its metabolites in feeds [17,25,26].

2.4. Method Validation

The method was successfully validated for all tested mycotoxins in feedstuffs (Table 1). Good specificity of the methods was confirmed by analysis of 20 pseudo-blank samples. No interference peaks (S/N > 3) were detected in the retention time (±2.5%) for targeted analytes. The determined LOD and LOQ for all analytes were in the 1.78–15.0 and 5.87–49.5 µg/kg ranges, respectively. These low LOD and LOQ for DON and its modified mycotoxins were comparable with those disclosed in other publications [23,44], or even lower [45]. The calibration curves were linear over the calibration range for all compounds, resulting in R2 values between 0.998 and 0.999. The REC was determined for each toxin based on a sample fortified at three VL (0.5 × VL, 1.0 × VL, and 1.5 × VL) and was above 90%, which fulfilled established criteria [46]. All values for repeatability and within-laboratory reproducibility were in the range of 4–24%, showing good precision for all toxins. Moreover, RSDr was between 4% and 22%, indicating that this method could be adopted for a wide range of feedstuffs. The expanded measurement uncertainty U (%) was satisfactory at below 35% for all tested toxins, showing acceptable method performance. Due to the large variability and complexity of the analysed samples, significant ME was expected [47]. In our study, ME values ranged from 61% to 120%. To compensate for this enhanced or suppressed signal, matrix-matched calibration curves were used as well as IS for DON and DON-3Glc. The MIX IS was added after extraction only to compensate for possible ME, to limit use of the expensive IS. This result shows that the developed procedure can be applied as a confirmatory method for determination of DON, its metabolites and others type B trichothecenes in feedstuffs.

2.5. Method Trueness, PT

Method trueness was evaluated by analysing three RMs (Table 2) and comparing them with the reference values. For each matrix, DON concentrations were in the uncertainty range of each sample. It is worth noting, that RMs were naturally contaminated samples, so other mycotoxins were also found. For example in the RM M15362D maize sample (Chiron) DON-3Glc, 3Ac-DON, 15Ac-DON and NIV were quantified at levels of 431, 19.0, 202, 203 µg/kg, respectively. Moreover, the molar ratios between DON-3Glc and 15-Ac to DON were high (43% and 20%, respectively). These results also indicate that if we analyse RM contaminated in real circumstances it is highly probably that metabolites of DON can be found and these data could be used for evaluation of method trueness. In the case of a PT organised by the European Union Reference Laboratory mycotoxins and plant toxins, z-score results obtained for samples (wheat and maize) were in a tolerable range −2 ≤ z ≤ 2 (−0.48 and 1.43). Thus, the developed method can produce accurate results in accordance with the reference values and could be applied in future to real contaminated feedstuff samples. It is worth to mention that in this PT acetylated forms of DON and DON-3Glc were covered only by less than half and one third of the laboratories, respectively. Also, false positive and negative results were reported related to 15Ac-DON, what indicate that determination of isomeric form is a challenge to analytical researchers.

2.6. Application to Real Contaminated Feedstuffs

The validated method was applied to the analysis of 99 feedstuff samples (Figure 5). DON and DON-3Glc were detected in 85% and 86% of surveyed samples and the mean concentrations were 511 µg/kg and 94.0 µg/kg, respectively (concentration ranging for DON between 10.1 and 1709 µg/kg and for DON-3Glc 1.70 and 385 µg/kg). Moreover, the ratio of the DON-3Glc concentration to that of DON ranged from 3% to 59% with a mean of 19%. The ratios of DON-3Glc/DON obtained in our study coincide with previously reported investigation [19,33]. The incidences of other toxins (3Ac-DON, 15Ac-DON, and NIV) were 35%, 26% and 23%, respectively.

3. Conclusions

A UHPLC-MS/MS method for the determination of DON, its metabolites and other type B trichothecenes in feedstuffs was successfully developed and validated. The main novelty of this method is that full separation of all compounds was achieved, including the isomeric forms 3Ac-DON and 15Ac-DON and that a DON-3Glc IS was used as the internal standard for quantification of DON-3Glc. In case of the IACs testing for they cross-reactivity features for DON modified forms none of them bound all derivatives and other toxins. The use of the commercially available Mycosep 225 columns allowed for quick and easy sample preparation. The results of RM analysis and the PT confirm the trueness of the method. Application of the validated method on feedstuffs revealed occurrence of DON and DON-3Glc in over 80% of positive samples. The developed method can be a tool for accurate qualification and quantification of mycotoxins and could be adopted as a confirmatory method for determination of DON and its modified mycotoxins NIV and FUS-X in a wide range of feedstuffs.

4. Materials and Methods

4.1. Chemicals and Standards

Six brands of IAC were compared for their cross-reactivity features: DONTest WB from Vicam, (Milford, MA, USA), DZT MS-PREP and DON PREP from R- Biopharm Rhone Ltd. (Glasgow, UK), B-TeZ IAC Deoxynivalenol from BioTeZ Berlin Buch GmbH (Berlin, Germany), DONStar from Romer Labs Diagnostic GmbH (Tulln, Austria) and aokinImmunoClean DON (DONaok) from Aokin AG (Berlin, Germany). DON PREP, B-TeZ IAC Deoxynivalenol and DONStar—were kindly provided free of charge by suppliers for testing purposes. Mycosep 225 Trich columns were purchased from Romer Labs Diagnostic GmbH. Oasis HLB cartridges were obtained from Waters (Milford, MA, USA). Acetonitrile (analytical and LC-MS grade; ACN), methanol (LC-MS grade; MeOH), acetic acid and C18 bulk sorbent were sourced from J.T. Baker of Avantor Performance Materials (Deventer, The Netherlands). Magnesium sulphate (MgSO4) was from Chempur (Piekary Śląskie, Poland) and water was prepared using a Milli-Q apparatus (MerckMillipore, Burlington, MA, USA) to attain purity of 18.2 MΩ. Mycotoxin standards of DON, U-[13C15] DON (DON IS), 3Ac-DON, 15Ac-DON, NIV and FUS-X were obtained from Sigma Aldrich (St. Louis, MO, USA). DON-3Glc and U-[13C21] DON-3G (DON-3Glc IS) were purchased from Romer Labs. The primary standard stock solutions were prepared in ACN. All standards were stored according to their manufacturer’s recommendations. The chloride and pottassioum chloride used to make phosphate buffered saline (PBS) were sourced from POCh (Gliwice, Poland) and the sodium hydrophosphate dehydrate from Chempur. PBS was made as follows: 8 g of sodium chloride, 3.6 g of sodium hydrophosphate dihydrate and 0.2 g of potassium chloride were dissolved in 1L of deionized water.

4.2. Mixed Working Solution

A mixed working solution (MIX6) was prepared in ACN from the individual stock of six mycotoxins at a concentration of 9 μg/mL for DON and NIV and 1 μg/mL for 3Ac-DON, 15Ac-DON, DON-3Glc and FUS-X. The internal standards solution (MIX IS) was mixed in ACN to achieve concentrations of 1 μg/mL and 0.5 μg/mL for DON IS and DON-3Glc IS, respectively. All working standard solutions were stored at 2–8 °C.

4.3. Samples and Reference Materials

Poultry and swine feedstuff samples (total n = 99) were collected in 2017 and 2018 by Veterinary Inspectorate officers working with feed manufacturers, in accordance to Commission Regulation (EC) NO. 2009/152 [48]. Delivered samples were milled using a ZM 200 ultra-centrifugal high-speed instrument with 1 mm sieve (Retsch GmbH, Haan, Germany;) and stored in a dark place at room temperature until analysis. A validation study was conducted using low contamination feed samples (pseudo-blanks) [49] with DON concentration of 50 ± 13 μg/kg (Figure 6).
For confirmation of the method trueness, three reference materials (RMs) were tested: maize (TET030RM; Fapas, Fera Science, York, UK), maize (12199.15-G; Chiron AS, Trondheim, Norway) and wheat (TET007RM; Fapas) (Table 2). Moreover, the method was verified in the “Deoxynivalenol and related compounds in food and feed matrices”; EURLPT-MP01 proficiency test on DON, 3Ac-DON, 15Ac-DON and DON-3Glc in wheat and maize carried out by the European Union Reference Laboratory mycotoxins and plant toxins.

4.4. IAC Testing

The cross-reactivity of six selected IAC was evaluated by loading 4 mL of water or PBS (according to the manufacturer’s recommendation) spiked with the MIX 6 mixed mycotoxin solution (at the level at which the analytes concerned could be extracted from samples). Next, the IAC was flushed with 4 mL of water and analytes were eluted with two portions of 1.5 mL of MeOH. The solvent was evaporated to dryness under a nitrogen stream at 40 °C and the dry residue was dissolved in 200 µL of 0.2% acetic acid and transferred to an autosampler vial. Each IAC was tested in triplicate. For comparison of their suitability for detection of the relevant mycotoxins, recovery was calculated as the ratio of the measured concentration of toxins to neat solvent.

4.5. Compared Strategies for Sample Preparation and Clean-Up

In addition to IACs, several other techniques of sample preparation have been tested: SLE, QuEChERS, SPE with OASIS HLB cartridges and Mycosep 225 Trich column (contain a mixture of adsorbent materials). The protocol for sample preparation for SLE and QuEChERS was based on our previously described methods [41,42].
The OASIS HLB column was tested according to the manufacturer’s protocol. Briefly, 1 g of sample was weighed into a 50 mL plastic tube and extracted for 30 min with 8 mL of H2O. Next, the sample was centrifuged and 2 mL of extract was transferred into OASIS HLB cartridges previously conditioned with 3 mL of MeOH and 3 mL of H2O. Subsequently, the column was washed with 5 mL of 5% MeOH and eluted with 3 mL of MeOH. All sample were collected and evaporated to dryness under a gentle nitrogen stream at 40 °C. The residue was dissolved in 200 µL of 0.2% CH3COOH and transferred to an autosampler vial.
For IAC DONTEST 1 g of sample was weighed into a 50 mL plastic tube and extracted for 30 min with 8 mL of H2O. Next, the sample was centrifuged and 2 mL of extract was passed onto DONTEST. Subsequently, the column was washed with 10 mL water and finally eluted with 2 mL methanol and collected to glass tube. After evaporation (N2, 40 °C) sample was dissolved in 200 µL of 0.2% CH3COOH and transferred to an autosampler vial.
For the sample preparation using for clean-up Mycosep 225 Trich column (based on the manufacturer’s recommendation with slight modification) 1 g of previously milled sample was weighed into a 50 mL centrifuge tube. Next, 8 mL of ACN:H2O (84:16; v/v) mixture was added and was extracted in a rotary shaker for 30 min, followed by centrifugation for 15 min at 4000 rpm. Subsequently, 6 mL of supernatant was transferred to a glass tube and pushed through a Mycosep 225 Trich column. Purified extract (2 mL) was collected, and the sample was evaporated to dryness in a gentle nitrogen stream at 40 °C. The dry residue was reconstituted in 200 µL of 0.2% CH3COOH and transferred to an autosampler vial. For final optimized sample preparation additionally, 10 µL of MIX IS was added before sample evaporation. Extraction recovery (ER) and matrix effect (ME) were calculated to find an appropriate method for sample preparation. In this case, ER was calculated as the ratio of the area of the analyte(s) recorded for the sample spiked with the target compound(s) before extraction to the area for the spiked sample after extraction.

4.6. LC-MS/MS Analysis

The analysis was performed with a Nexera X2 system with an LCMS-8050 triple-quadrupole mass spectrometer (Shimadzu, Kioto, Japan). LabSolutions software (version 5.60 SP2, Shimadzu, Kioto, Japan) was used for data acquisition and processing. Chromatographic separation was tested using four chromatographic columns with the different stationary and mobile phase composition (Table S2). Column and autosampler temperatures were set at 45 °C and 4 °C, respectively. The final optimised mobile phase A consisted of 0.2% CH3COOH in water/ACN (95:5; v/v) (eluent A) and ACN/0.2% CH3COOH in water (95:5; v/v) (eluent B). A gradient elution was used as follows: 0–2 min 15% B, 2.1–6 min 18% B, 6.1–9 min isocratic step at 100% B, and 9.1–12 min 0% B. The total run time was 12 min at a flow rate of 0.3 mL/min and the injection volume was 5 µL.
The mass spectrometry detection was carried out using multiple reaction monitoring (MRM) with positive and negative electrospray ionization (ESI+/−) (Table S2). The following ion-source settings were used: nebulising gas flow: 2 L/ min, heating gas flow: 10 L/min, drying gas flow: 10 L/min, interface temperature: 300 °C, desolvation line temperature: 250 °C, heat block temperature: 400 °C, and Q1 and Q3 resolution: Unit.
The identification of the analyte was performed according to the SANTE/12089 /2016 Guidance document on identification of mycotoxins in food and feed [50]. Four identification criteria were used: comparison of peak retention time in test samples with retention times of calibration standards; the retention time of the internal standard being within the tolerance range ±0.05 min relative to the appropriate standard; selection of at least two characteristic fragmentary ions and calculation of their ion ratio (within ±30% (relative) of average of calibration standards from the same sequence); and the peaks having an S/N ratio of at least 3.

4.7. Method Validation

The method was validated for feedstuffs and the following parameters were verified and calculated: specificity, limit of detection (LOD) and quantification (LOQ), linearity, apparent recovery (REC, %), precision as repeatability (RSD, CV%) and within-laboratory reproducibility (RSDr, CV%), trueness and matrix effect (ME, %) [46,50]. All validation parameters were calculated using the relative peak area with respect to DON IS and DON-3Glc IS. The specificity was checked by analysing 20 different pseudo-blank feed samples to evaluate possible interferences. LOD and LOQ were also calculated based on Guidance Document on the Estimation of LOD and LOQ for Measurements in the Field of Contaminants in Feed and Food using paired observation approach [27]. The three validation levels (VL) 0.5 × VL, 1.0 × VL, and 1.5 × VL used for DON and NIV were: 450, 900, and 1350 µg/kg, and for DON-3Glc, 3Ac-DON, 15Ac-DON and FUS-X they were: 50, 100, and 150 µg/kg. The decisions on fortification levels for each analyte were made on basis of the lowest guidance value EU in feedstuffs (only for DON, 900 µg/kg) [8]. For other toxins—based on concentration data in feedstuffs reported by others authors [13,18,35] and LC-MS/MS detection. The linearity was determined using a matrix-matched calibration plot. The concentration ranges of the five-point calibration curves were 90–1800 μg/kg for DON and NIV and 10–200 μg/kg for DON-3Glc 3Ac-DON, 15Ac-DON and 50–200 μg/kg for FUS-X. The REC (apparent recovery) was calculated by quantifying the mycotoxins using matrix-matched calibration curves at the three VL. For the repeatability study, one kind of pseudo-blank feedstuff was spiked at three levels in six repetitions. The within-laboratory reproducibility was assessed by analysis of six different feedstuffs for animals (wheat, maize, feedstuffs for pigs, poultry, fish and mixed cereals) at the three VL on different days by two operators. Trueness was evaluated by analysing three RM in duplicate (Table 2).
To evaluate the ME, six different pseudo-blank samples were extracted with the proposed procedure and spiked after extraction with pure standards of all tested mycotoxins at the same level as in the within-laboratory reproducibility study. The responses of the mycotoxins were compared to a neat standard solution. With such a calculation, the ratio of 1:1 (100%) would mean no matrix effects, ion enhancement would result in a ratio above 100%, and ion suppression in a ratio below 100%. To compensate for possible losses caused by ME, DON IS was used for quantification of DON, NIV, 3-AcDON, 15Ac-DON, FUS-X and DON-3Glc IS for DON-3Glc. Additionally, the expanded measurement uncertainty (U) was calculated with MUkit software (Envical SYKE, Helsinki, Finland) for the 1.0 × VL spiking level using the Nordtest approach [51].

Supplementary Materials

The following are available online at https://0-www-mdpi-com.brum.beds.ac.uk/2072-6651/12/6/362/s1, Table S1: LC-MS/MS parameters for detection of mixed mycotoxins by the mass spectrometer; Table S2: LC column used during the chromatographic set up.

Author Contributions

Investigation, Ł.P.; Methodology, Ł.P. and K.P.; Writing—original draft, Ł.P.; Writing—review & editing, P.J. and A.P. All authors have read and agreed to the published version of the manuscript.

Funding

Funded by the KNOW (Leading National Research Centre) Scientific Consortium ‘Healthy Animal–Safe Food’, a decision of the Ministry of Science and Higher Education No. 05-1/KNOW2/2015.

Conflicts of Interest

The authors declare no conflict of interest.

References

  1. Streit, E.; Schatzmayr, G.; Tassis, P.; Tzika, E.; Marin, D.; Taranu, I.; Tabuc, C.; Nicolau, A.; Aprodu, I.; Puel, O.; et al. Current situation of mycotoxin contamination and co-occurrence in animal feed focus on Europe. Toxins 2012, 4, 788–809. [Google Scholar] [CrossRef] [PubMed] [Green Version]
  2. Sugita-Konishi, Y.; Park, B.J.; Kobayashi-Hattori, K.; Tanaka, T.; Chonan, T.; Yoshikava, K.; Kumagai, S. Effect of Cooking Process on the Deoxynivalenol Content and Its Subsequent Cytotoxicity in Wheat Products. Biosci. Biotechnol. Biochem. 2006, 70, 1764–1768. [Google Scholar] [CrossRef] [PubMed] [Green Version]
  3. Pestka, J.J. Deoxynivalenol: Toxicity, mechanisms and animal health risks. Anim. Feed Sci. Technol. 2007, 137, 283–298. [Google Scholar] [CrossRef]
  4. Rychlik, M.; Humpf, H.U.; Marko, D.; Dänicke, S.; Mally, A.; Berthiller, F.; Klaffke, H.; Lorenz, N. Proposal of a comprehensive definition of modified and other forms of mycotoxins including “masked” mycotoxins. Mycotoxin Res. 2014, 30, 197–205. [Google Scholar] [CrossRef] [PubMed] [Green Version]
  5. Berthiller, F.; Crews, C.; Dall’Asta, C.; de Saeger, S.; Haesaert, G.; Karlovsky, P.; Oswald, I.P.; Seefelder, W.; Speijers, G.; Stroka, J. Masked mycotoxins: A review. Mol. Nutr. Food Res. 2013, 57, 165–186. [Google Scholar] [CrossRef]
  6. Freire, L.; Sant’Ana, A.S. Modified mycotoxins: An updated review on their formation, detection, occurrence, and toxic effects. Food Chem. Toxicol. 2018, 111, 189–205. [Google Scholar] [CrossRef]
  7. Broekaert, N.; Devreese, M.; Demeyere, K.; Berthiller, F.; Michlmayr, H.; Varga, E.; Adam, G.; Meyer, E.; Croubels, S. Comparative in vitro cytotoxicity of modified deoxynivalenol on porcine intestinal epithelial cells. Food Chem. Toxicol. 2016, 95, 103–109. [Google Scholar] [CrossRef]
  8. European Commission. Commission Recommendation 2006/576/EC of 17 August 2006 on the Presence of Deoxynivalenol, Zearalenone, Ochratoxin A, T-2 and HT-2 and Fumonisins in Products Intended for Animal Feeding; Office of the European Union: Brussels, Belgium, 2006; Volume 229, pp. 7–9. [Google Scholar]
  9. European Commission. Commision Recommendation 2016/ 1319 of 29 July 2016—Amending Recommendation 2006/ 576/ EC as Regards Deoxynivalenol, Zearalenone and Ochratoxin A in Pet Food; Office of the European Union: Brussels, Belgium, 2016; Volume 73, pp. 58–60. Available online: http://eur-lex.europa.eu/legal-content/EN/TXT/PDF/?uri=CELEX:32016H1319&from=EN (accessed on 29 May 2020).
  10. European Food Safety Authority (EFSA). Scientific Opinion on risks for animal and public health related to the presence of nivalenol in food and feed. EFSA J. 2013, 11, 3262. [Google Scholar] [CrossRef]
  11. European Food Safety Authority (EFSA). Risks to human and animal health related to the presence of deoxynivalenol and its acetylated and modified forms in food and feed. EFSA J. 2017, 15. [Google Scholar] [CrossRef]
  12. European Food Safety Authority (EFSA). Scientific Opinion on the risks for human and animal health related to the presence of modified forms of certain mycotoxins in food and feed. EFSA J. 2014, 12. [Google Scholar] [CrossRef] [Green Version]
  13. Zhao, Z.; Rao, Q.; Song, S.; Liu, N.; Han, Z.; Hou, J.; Wu, A. Simultaneous determination of major type B trichothecenes and deoxynivalenol-3-glucoside in animal feed and raw materials using improved DSPE combined with LC-MS/MS. J. Chromatogr. B Anal. Technol. Biomed. Life Sci. 2014, 963, 75–82. [Google Scholar] [CrossRef] [PubMed]
  14. Chen, D.; Cao, X.; Tao, Y.; Wu, Q.; Pan, Y.; Peng, D.; Liu, Z.; Huang, L.; Wang, Y.; Wang, X.; et al. Development of a liquid chromatography—Tandem mass spectrometry with ultrasound-assisted extraction and auto solid-phase clean-up method for the determination of Fusarium toxins in animal derived foods. J. Chromatogr. A 2013, 1311, 21–29. [Google Scholar] [CrossRef] [PubMed]
  15. Yoshinari, T.; Tanaka, T.; Ishikuro, E.; Horie, M.; Nagayama, T.; Nakajima, M.; Naito, S.; Ohnishi, T.; Sugita-Konishi, Y. Inter-laboratory Study of an LC-MS/MS Method for Simultaneous Determination of Deoxynivalenol and Its Acetylated Derivatives, 3-Acetyl-deoxynivalenol and 15-Acetyl-deoxynivalenol in Wheat. Shokuhin Eiseigaku Zasshi 2013, 54, 75–82. [Google Scholar] [CrossRef] [Green Version]
  16. Vendl, O.; Berthiller, F.; Crews, C.; Krska, R. Simultaneous determination of deoxynivalenol, zearalenone, and their major masked metabolites in cereal-based food by LC-MS-MS. Anal. Bioanal. Chem. 2009, 395, 1347–1354. [Google Scholar] [CrossRef] [PubMed]
  17. Gonçalves, C.; Stroka, J. Cross-reactivity features of deoxynivalenol (DON)-targeted immunoaffinity columns aiming to achieve simultaneous analysis of DON and major conjugates in cereal samples. Food Addit. Contam. Part A 2016, 33, 1053–1062. [Google Scholar] [CrossRef] [PubMed]
  18. Pascale, M.; Panzarini, G.; Powers, S.; Visconti, A. Determination of Deoxynivalenol and Nivalenol in Wheat by Ultra-Performance Liquid Chromatography/Photodiode-Array Detector and Immunoaffinity Column Cleanup. Food Anal. Methods 2014, 7, 555–562. [Google Scholar] [CrossRef]
  19. Bryła, M.; Ksieniewicz-Woźniak, E.; Waśkiewicz, A.; Szymczyk, K.; Jędrzejczak, R. Natural Occurrence of Nivalenol, Deoxynivalenol, and Deoxynivalenol-3-Glucoside in Polish Winter Wheat. Toxins 2018, 10, 81. [Google Scholar] [CrossRef] [Green Version]
  20. Trombete, F.; Barros, A.; Vieira, M.; Saldanha, T.; Venâncio, A.; Fraga, M. Simultaneous Determination of Deoxynivalenol, Deoxynivalenol-3-Glucoside and Nivalenol in Wheat Grains by HPLC-PDA with Immunoaffinity Column Cleanup. Food Anal. Methods 2016, 9, 2579–2586. [Google Scholar] [CrossRef] [Green Version]
  21. De Boevre, M.; van Poucke, C.; Ediage, E.N.; Vanderputten, D.; van Landschoot, A.; de Saeger, S. Ultra-High-Performance Supercritical Fluid Chromatography as a Separation Tool for Fusarium Mycotoxins and Their Modified Forms. J. AOAC Int. 2018, 101, 627–632. [Google Scholar] [CrossRef]
  22. Righetti, L.; Paglia, G.; Galaverna, G.; Dall’Asta, C. Recent Advances and Future Challenges in Modified Mycotoxin Analysis: Why HRMS Has Become a Key Instrument in Food Contaminant Research. Toxins 2016, 8, 361. [Google Scholar] [CrossRef]
  23. De Boevre, M.; di Mavungu, J.D.; Maene, P.; Audenaert, K.; Deforce, D.; Haesaert, G.; Eeckhout, M.; Callebaut, A.; Berthiller, F.; van Peteghem, C.; et al. Development and validation of an LC-MS/MS method for the simultaneous determination of deoxynivalenol, zearalenone, T-2-toxin and some masked metabolites in different cereals and cereal-derived food. Food Addit. Contam. Part A 2012, 29, 819–835. [Google Scholar] [CrossRef] [PubMed]
  24. Dzuman, Z.; Zachariasova, M.; Lacina, O.; Veprikova, Z.; Slavikova, P.; Hajslova, J. A rugged high-throughput analytical approach for the determination and quantification of multiple mycotoxins in complex feed matrices. Talanta 2014, 121, 263–272. [Google Scholar] [CrossRef] [PubMed]
  25. Li, Y.; Wang, Z.; de Saeger, S.; Shi, W.; Li, C.; Zhang, S.; Cao, X.; Shen, J. Determination of deoxynivalenol in cereals by immunoaffinity clean-up and ultra-high performance liquid chromatography tandem mass spectrometry. Methods 2012, 56, 192–197. [Google Scholar] [CrossRef] [PubMed]
  26. Suman, M.; Bergamini, E.; Catellani, D.; Manzitti, A. Development and validation of a liquid chromatography/linear ion trap mass spectrometry method for the quantitative determination of deoxynivalenol-3-glucoside in processed cereal-derived products. Food Chem. 2013, 136, 1568–1576. [Google Scholar] [CrossRef] [PubMed]
  27. Veršilovskis, A.; Geys, J.; Huybrechts, B.; Goossens, E.; de Saeger, S.; Callebaut, A. Simultaneous determination of masked forms of deoxynivalenol and zearalenone after oral dosing in rats by LC-MS/MS. World Mycotoxin J. 2012, 5, 303–318. [Google Scholar] [CrossRef]
  28. Andrade, P.D.; Dantas, R.R.; de Moura-Alves, T.L.D.; Caldas, E.D. Determination of multi-mycotoxins in cereals and of total fumonisins in maize products using isotope labeled internal standard and liquid chromatography/tandem mass spectrometry with positive ionization. J. Chromatogr. A 2017, 1490, 138–147. [Google Scholar] [CrossRef] [PubMed]
  29. Fan, Z.; Bai, B.; Jin, P.; Fan, K.; Guo, W.; Zhao, Z.; Han, Z. Development and Validation of an Ultra-High Performance Liquid Chromatography-Tandem Mass Spectrometry Method for Simultaneous Determination of Four Type B Trichothecenes and Masked Deoxynivalenol in Various Feed Products. Molecules 2016, 21, 747. [Google Scholar] [CrossRef] [PubMed]
  30. Radová, Z.; Holadová, K.; Hajšlová, J. Comparison of two clean-up principles for determination of trichothecenes in grain extract. J. Chromatogr. A 1998, 829, 259–267. [Google Scholar] [CrossRef]
  31. Lattanzio, V.M.T.; Ciasca, B.; Powers, S.; Visconti, A. Improved method for the simultaneous determination of aflatoxins, ochratoxin A and Fusarium toxins in cereals and derived products by liquid chromatography-tandem mass spectrometry after multi-toxin immunoaffinity clean up. J. Chromatogr. A 2014, 1354, 139–143. [Google Scholar] [CrossRef]
  32. Nathanail, A.V.; Sarikaya, E.; Jestoi, M.; Godula, M.; Peltonen, K. Determination of deoxynivalenol and deoxynivalenol-3-glucoside in wheat and barley using liquid chromatography coupled to mass spectrometry: On-line clean-up versus conventional sample preparation techniques. J. Chromatogr. A 2014, 1374, 31–39. [Google Scholar] [CrossRef]
  33. Berthiller, F.; Dalla’sta, C.; Corradini, R.; Marchelli, R.; Sulyok, M.; Krska, R.; Adam, A.; Schuhmacher, R. Occurrence of deoxynivalenol and its 3-ß-D-glucoside in wheat and maize. Food Addit. Contam. 2009, 26, 507–511. [Google Scholar] [CrossRef] [PubMed] [Green Version]
  34. Broekaert, N.; Devreese, M.; de Mil, T.; Fraeyman, S.; de Baere, S.; de Saeger, S.; de Backer, P.; Croubels, S. Development and validation of an LC – MS / MS method for the toxicokinetic study of deoxynivalenol and its acetylated derivatives in chicken and pig plasma. J. Chromatogr. B 2014, 971, 43–51. [Google Scholar] [CrossRef] [PubMed]
  35. Yoshinari, T.; Ohnishi, T.; Kadota, T.; Sugita-Konishi, Y. Development of a Purification Method for Simultaneous Determination of Deoxynivalenol and Its Acetylated and Glycosylated Derivatives in Corn Grits and Corn Flour by Liquid Chromatography–Tandem Mass Spectrometry. J. Food Prot. 2012, 75, 1355–1358. [Google Scholar] [CrossRef] [PubMed]
  36. Neuhof, T.; Ganzauer, N.; Koch, M.; Nehls, I. A Comparison of Chromatographic Methods for the Determination of Deoxynivalenol in Wheat. Chromatographia 2009, 69, 1457–1462. [Google Scholar] [CrossRef]
  37. Slobodchikova, I.; Vuckovic, D. Liquid chromatography—High resolution mass spectrometry method for monitoring of 17 mycotoxins in human plasma for exposure studies. J. Chromatogr. A 2018, 1548, 51–63. [Google Scholar] [CrossRef] [Green Version]
  38. Goryacheva, I.Y.; de Saeger, S. Immunochemical detection of masked mycotoxins: A short review. World Mycotoxin J. 2012, 5, 281–287. [Google Scholar] [CrossRef]
  39. Veršilovskis, A.; Huybrecht, B.; Tangni, E.K.; Pussemier, L.; de Saeger, S.; Callebaut, A. Cross-reactivity of some commercially available deoxynivalenol (DON) and zearalenone (ZEN) immunoaffinity columns to DON- and ZEN-conjugated forms and metabolites. Food Addit. Contam. Part A Chem. Anal. Control. Exp. Risk Assess. 2011, 28, 1687–1693. [Google Scholar] [CrossRef]
  40. Uhlig, S.; Stanic, A.; Hussain, F.; Miles, C.O. Selectivity of commercial immunoaffinity columns for modified forms of the mycotoxin 4-deoxynivalenol (DON). J. Chromatogr. B Anal. Technol. Biomed. Life Sci. 2017, 1061, 322–326. [Google Scholar] [CrossRef]
  41. Panasiuk, L.; Jedziniak, P.; Pietruszka, K.; Piatkowska, M.; Bocian, L. Frequency and levels of regulated and emerging mycotoxins in silage in Poland. Mycotoxin Res. 2019, 35, 17–25. [Google Scholar] [CrossRef] [Green Version]
  42. Jedziniak, P.; Panasiuk, Ł.; Pietruszka, K.; Posyniak, A. Multiple mycotoxins analysis in animal feed with LC-MS/MS: Comparison of extract dilution and immunoaffinity clean-up. J. Sep. Sci. 2019, 42, 1240–1247. [Google Scholar] [CrossRef]
  43. Malachova, A.; Sulyok, M.; Schuhmacher, R.; Berthiller, F.; Hajslova, J.; Veprikova, Z.; Zachariasova, M.; Lattanzio, V.M.T.; de Saeger, S.; di Mavungu, J.D.; et al. Collaborative investigation of matrix effects in mycotoxin determination by high performance liquid chromatography coupled to mass spectrometry. Qual. Assur. Saf. Crops Foods 2013, 5, 91–103. [Google Scholar] [CrossRef]
  44. Geng, Z.; Yang, D.; Zhou, M.; Zhang, P.; Wang, D.; Liu, F.; Zhu, Y.; Zhang, M. Determination of Deoxynivalenol-3-Glucoside in Cereals by Hydrophilic Interaction Chromatography with Ultraviolet Detection. Food Anal. Methods 2013, 7, 1139–1146. [Google Scholar] [CrossRef]
  45. Xu, J.J.; Zhou, J.; Huang, B.F.; Cai, Z.X.; Xu, X.M.; Ren, Y.P. Simultaneous and rapid determination of deoxynivalenol and its acetylate derivatives in wheat flour and rice by ultra high performance liquid chromatography with photo diode array detection. J. Sep. Sci. 2016, 39, 2028–2035. [Google Scholar] [CrossRef]
  46. European Commission. Commission Regulation (EC) No 401/2006 of 23 February 2006 Laying down the Methods of Sampling and Analysis for the Official Control of the Levels of Mycotoxins in Foodstuffs; Office of the European Union: Brussels, Belgium, 2006; Volume 2006, pp. 12–34. [Google Scholar]
  47. Matuszewski, B.K.; Constanzer, M.L.; Chavez-Eng, C.M. Strategies for the Assessment of Matrix Effect in Quantitative Bioanalytical Methods Based on HPLC−MS/MS. Anal. Chem. 2003, 75, 3019–3030. [Google Scholar] [CrossRef] [PubMed]
  48. European Commission. Commission regulation (EC) No 152/2009 of 27 January 2009 Laying down the Methods of Sampling and Analysis for the Official Control of Feed; Office of the European Union: Brussels, Belgium, 2009; Volume 36, pp. 1–130. [Google Scholar]
  49. Haedrich, J.; Wenzl, T.; Schaechtele, A.; Robouch, P.; Stroka, J. Guidance Document on the Estimation of LOD and LOQ for Measurements in the Field of Contaminants in Feed and Food; Publications Office of the European Union: Luxembourg, 2016. [Google Scholar] [CrossRef]
  50. European Commission (EC). Guidance Document on Identification of Mycotoxins in Food and Feed; Office of the European Union: Brussels, Belgium, 2017; pp. 1–4. [Google Scholar]
  51. Magnusson, B.; Näykki, T.; Hovind, H.; Krysell, M.; Sahlin, E. Nordtest, Handbook for Calculation of Measurement Uncertainty in Environmental Laboratories, 4th ed.; NT TR 537; Nordtest: Taastrup, Denmark, 2017; Volume 4. [Google Scholar]
Figure 1. LC–MS/MS chromatograms of analysed toxins, tested in the same mobile phase but at different chromatographic columns: (A) Phenomenex Luna HILIC (B) Phenomenex Kinetex Biphenyl 100 × 2.1mm, 1.7 µm; (C) Phenomenex Kinetex C18 100 × 2.6 mm, 2.1 µm.
Figure 1. LC–MS/MS chromatograms of analysed toxins, tested in the same mobile phase but at different chromatographic columns: (A) Phenomenex Luna HILIC (B) Phenomenex Kinetex Biphenyl 100 × 2.1mm, 1.7 µm; (C) Phenomenex Kinetex C18 100 × 2.6 mm, 2.1 µm.
Toxins 12 00362 g001
Figure 2. Chromatographic separation of tested compounds on the same column (Phenomenex Luna ® Omega C18 100 × 2.1, 1.6 µm) with different organic mobile phase: (A) MeOH; (B) ACN.
Figure 2. Chromatographic separation of tested compounds on the same column (Phenomenex Luna ® Omega C18 100 × 2.1, 1.6 µm) with different organic mobile phase: (A) MeOH; (B) ACN.
Toxins 12 00362 g002
Figure 3. Mycotoxins recoveries obtained with IACs columns available on the market, obtained from different suppliers.
Figure 3. Mycotoxins recoveries obtained with IACs columns available on the market, obtained from different suppliers.
Toxins 12 00362 g003
Figure 4. Extraction recovery (ER) and matrix effect (ME) of the tested methods for sample preparation.
Figure 4. Extraction recovery (ER) and matrix effect (ME) of the tested methods for sample preparation.
Toxins 12 00362 g004
Figure 5. The mycotoxins concentrations in contaminated feedstuffs (n = 99).
Figure 5. The mycotoxins concentrations in contaminated feedstuffs (n = 99).
Toxins 12 00362 g005
Figure 6. Chromatogram of pseudo-blank sample with DON concentration of 50 ± 13 μg/kg.
Figure 6. Chromatogram of pseudo-blank sample with DON concentration of 50 ± 13 μg/kg.
Toxins 12 00362 g006
Table 1. Validation parameters for the analysed mycotoxins in feedstuffs.
Table 1. Validation parameters for the analysed mycotoxins in feedstuffs.
REC (%)ME (%)Calibration Range(µg/kg)R2 Precision (CV, %) LOD
(µg/kg)
LOQ
(µg/kg)
U
(%)
RSDRSDr
0.5 × VL1.0 × VL1.5 × VL0.5 × VL1.0 × VL1.5 × VL0.5 × VL1.0 × VL1.5 × VL0.5 × VL1.0 × VL1.5 × VL
DON104 ± 493 ± 699 ± 682 ± 12101 ± 17%87 ± 890–18000.999991147610.133.326.0
DON-3Glc93 ± 1092 ± 1296 ± 1078 ± 1261 ± 15%74 ± 1410–2000.999208131015101.785.8712.0
3Ac-DON105 ± 1294 ± 6104 ± 10109 ± 7119 ± 20%113 ± 710–2000.999999127102.438.0226.0
15Ac-DON97 ± 1292 ± 1690 ± 18115 ± 15120 ± 16%111 ± 1210–2000.99949132219215.6518.625.0
NIV106 ± 1497 ± 1594 ± 1596 ± 685 ± 7%89 ± 690–18000.9991613241319173.3010.925.0
FUS-X101 ± 1293 ± 1296 ± 1193 ± 6104 ± 15%88 ± 850–2000.99869108161415.049.535.0
Table 2. Trueness of results obtained by the developed method; mycotoxins concentration determined in proficiency testing materials (EURL) and RMs.
Table 2. Trueness of results obtained by the developed method; mycotoxins concentration determined in proficiency testing materials (EURL) and RMs.
Reference SampleMatrixAnalyteReference Concentration (µg/kg)Concentration Uncertainty (µg/kg)Measured Concentration (µg/kg) aCalculated z-Score
Proficiency Test EURLPT-MP01wheatDON570±14.8502−0.48
DON-3Glc215±22.2217−0.04
3Ac-DON35.2±2.4032.0−0.37
maizeDON751±20.4729−0.12
DON-3Glc35.0±1.4847.51.43
3Ac-DON92.8±3.7190.2−0.11
15Ac-DON152±11.51590.18
RM M15362D (Chiron)maizeDON1077±73.0993---
DON-3Glc------431---
3Ac-DON------19.0---
15Ac-DON------202---
NIV------203---
RM TET007RM (Fapas)wheatDON1810±3111956---
DON-3Glc------125---
RM TET030RM (Fapas)maizeDON1208±1171077---
DON-3Glc------190---
15Ac-DON------121---
a measured in duplicate

Share and Cite

MDPI and ACS Style

Panasiuk, Ł.; Jedziniak, P.; Pietruszka, K.; Posyniak, A. Simultaneous Determination of Deoxynivalenol, Its Modified Forms, Nivalenol and Fusarenone-X in Feedstuffs by the Liquid Chromatography–Tandem Mass Spectrometry Method. Toxins 2020, 12, 362. https://0-doi-org.brum.beds.ac.uk/10.3390/toxins12060362

AMA Style

Panasiuk Ł, Jedziniak P, Pietruszka K, Posyniak A. Simultaneous Determination of Deoxynivalenol, Its Modified Forms, Nivalenol and Fusarenone-X in Feedstuffs by the Liquid Chromatography–Tandem Mass Spectrometry Method. Toxins. 2020; 12(6):362. https://0-doi-org.brum.beds.ac.uk/10.3390/toxins12060362

Chicago/Turabian Style

Panasiuk, Łukasz, Piotr Jedziniak, Katarzyna Pietruszka, and Andrzej Posyniak. 2020. "Simultaneous Determination of Deoxynivalenol, Its Modified Forms, Nivalenol and Fusarenone-X in Feedstuffs by the Liquid Chromatography–Tandem Mass Spectrometry Method" Toxins 12, no. 6: 362. https://0-doi-org.brum.beds.ac.uk/10.3390/toxins12060362

Note that from the first issue of 2016, this journal uses article numbers instead of page numbers. See further details here.

Article Metrics

Back to TopTop