Next Article in Journal
Blackcurrant (Ribes nigrum L.) and Kamchatka Honeysuckle (Lonicera caerulea var. Kamtschatica) Extract Effects on Technological Properties, Sensory Quality, and Lipid Oxidation of Raw-Cooked Meat Product (Frankfurters)
Next Article in Special Issue
Challenge Test as Special Tool to Estimate the Dynamic of Listeria monocytogenes and Other Foodborne Pathogens
Previous Article in Journal
Synergy of Nitric Oxide and 1-Methylcyclopropene Treatment in Prolong Ripening and Senescence of Peach Fruit
Previous Article in Special Issue
Emerging Risks in Food: Probiotic Enterococci Pose a Threat to Public Health through the Food Chain
 
 
Font Type:
Arial Georgia Verdana
Font Size:
Aa Aa Aa
Line Spacing:
Column Width:
Background:
Communication

Bacillus cereus as a Major Cause of Discarded Pasteurized Human Banked Milk: A Single Human Milk Bank Experience

1
Tissue Bank, University Hospital Hradec Králové, 500 05 Hradec Králové, Czech Republic
2
Department of Histology and Embryology, Faculty of Medicine in Hradec Králové, Charles University, 500 03 Hradec Králové, Czech Republic
3
Food Research Institute Prague, 102 00 Prague, Czech Republic
4
Department of Clinical Microbiology, University Hospital and Faculty of Medicine in Hradec Králové, Charles University, 500 05 Hradec Králové, Czech Republic
5
Department of Hospital Hygiene, University Hospital Hradec Králové, 500 05 Hradec Králové, Czech Republic
6
Department of Pediatrics, University Hospital Hradec Králové, 500 05 Hradec Králové, Czech Republic
7
Department of Obstetrics and Gynecology, University Hospital Hradec Králové, 500 05 Hradec Králové, Czech Republic
*
Author to whom correspondence should be addressed.
Submission received: 21 October 2021 / Revised: 17 November 2021 / Accepted: 26 November 2021 / Published: 1 December 2021
(This article belongs to the Special Issue Microbiological Risk Assessment in Foods)

Abstract

:
A systematic study, performed from 2017–2020 looked at the rate of positive post-pasteurization B. cereus findings, the quantity of B. cereus in pasteurized banked human milk (PBM), and the rate of B. cereus toxicogenic isolates from PBM. During the study period, 6815.71 L (30,943 tested bottles) of PBM were tested, with an average amount per year of 1703.93 L (7736 tested bottles). The PBM discard rate per year due to bacterial contamination varied between 8.7–10.0% and contamination with B. cereus was the most frequent reason. The total number of B. cereus positive tests was 2739 and the proportion of its positivity from all positive tests was between 56.7–66.6%. The prevalence of B. cereus positive tests rose significantly in the summer months. The production of enterotoxin was found in 3 of the 20 tested samples (15.0%). The B. cereus CFU-quantities in the PBM were below 10 CFU/mL in 80% of cases (16 of 20 samples tested). The quantitative data can be used in the risk assessment of cold storage of PBM at temperatures above zero and manipulation of PBM prior to its administration.

1. Introduction

B. cereus is a motile aerobic or facultatively anaerobic, spore-forming Gram-positive bacterium. It is found in the environment, air, dust, and water and is a common contaminant of food [1], including milk formulas [2,3,4,5]. Some of its strains are toxicogenic [2,6,7]. B. cereus is responsible for two types of food poisoning: diarrheal syndrome and emetic syndrome [7,8]. B. cereus is an opportunistic human pathogen associated with local and systemic infections in immunosuppressed patients. Premature infants are highly susceptible to infection due to their poorly developed immune system and prolonged invasive procedures, such as mechanical ventilation or catheterization [9,10]. Infections of the bloodstream, lungs, central nervous system [1,11,12,13,14], and intestinal tract [2] have been described, some with fatal outcomes [9,15]. The bacterium is resistant to standard cleaning procedures used in the food industry and hospitals as well to pasteurization [7,16,17,18,19,20]. Decousser et al. first described the presence of pathogenic strains of B. cereus in pasteurized banked milk [2]. In recent years several studies described B. cereus as a frequent cause of PBM discard after Holder pasteurization that is used in most Human Milk Banks [20,21,22]. Experiments were performed with other pasteurization regimens, no evidence of their better efficiency on B. cereus was presented, however [22]. High-pressure inactivation [23] seems to be a promising method for the future. Since outbreaks of B. cereus infection occur in neonatal intensive care units, PBM becomes a suspect source of infection [16,24]. However, PBM was never confirmed as a source of B. cereus infection in newborns. Nevertheless, especially the latter case from August/September 2016 [24] led to increased interest in detecting B. cereus in PBM and in identifying potential sources of B. cereus infection in newborns. Fournier et al. analyzed nine cases of B. cereus bacteremia that occurred in neonatal intensive care units of five French hospitals from August till December 2016 and reviewed the corrective actions made in the hospitals and in the Human Milk Bank [24]. Glasset et al. [19] presented the results of the 5-year retrospective study of B. cereus infections detected in nine hospitals from different regions of France in the years 2008–2012. B. cereus was found in cultures taken from 39 patients, 41% of them were newborns. The authors point out the clinical significance of positive B. cereus findings in the environment of hospitals, which was generally underestimated in the past. Recently Cormontagne et al. published an extensive review summarizing the spectrum of possible B. cereus infections in premature newborns, the possible sources of B. cereus in the environment of hospitals including contaminated medical devices used in pediatric intensive care units, as well as the data on post-pasteurization contamination of human milk in French Human Milk Banks [20]. In this review, B. cereus was reported to be the leading cause of PBM discard that varied between 13.9% and 21.2% in the years 2016 to 2019. B. cereus was found in 80 to 90% of discarded batches [20]. Similarly to the above-cited authors, we have paid particular attention to the presence of B. cereus in PBM processed in our Milk Bank since the end of 2016. In 2017 we introduced an improved method of detection of all strains surviving pasteurization using the MALDI mass spectrometry method. This paper presents the results of a 4-year systematic study performed from 2017 to 2020 that focused exclusively on human milk banking issues: 1. Frequency of all microbial strains surviving pasteurization after the introduction of the MALDI method; 2. The proportion of PBM contamination caused by the Bacillus genus and particularly by B. cereus of the total PBM contamination and its seasonal prevalence; 3. The quantity of B. cereus in milk discarded due to B. cereus positivity; 4. The frequency of B. cereus strains producing enterotoxin in isolates from B. cereus positive milk. The post-pasteurization B. cereus quantity and toxigenicity were investigated in two prospective studies performed in 2020.

2. Materials and Methods

2.1. The Human Milk Bank Quality Management System

In 2004, we implemented a Hazard Analysis and Critical Control Points system (HACCP) [25,26], which has been regularly updated. This system is compliant with the requirements of the Regulation of the European Parliament No. 852/2004, Council on Hygiene of Food and Regulation of the European Commission No. 2073/2005, and the Decree of Ministry of Health of the Czech Republic No. 602/2006 Coll. A first version of HACCP handbook was written in the same year. Besides the analysis of physical, chemical and especially microbiological risk during the collection, processing, storage, and distribution of PBM this handbook implemented the basic principles of good manufacturing practice, such as the use of regularly validated equipment, continuous monitoring and recording of critical parameters, prevention of secondary contamination during processing by the use of a laminar flow cabinet and release of each batch for clinical application by a qualified person. A predictive mathematical model was used to assess the bacteriological risk during the manipulation of pasteurized human milk [25]. The HACCP handbook for our milk bank includes a schematic description of the manufacturing process with marked control points. The last update of the handbook in 2016 included improvements in bacteriological diagnostics using the MALDI method, leading to a more precise microbiological risk assessment.

2.2. Human Milk Collection and Receipt by the Milk Bank

Milk collection was performed on mothers hospitalized with their newborns requiring intensive care in the pediatric department or the homes of external milk donors. Milk was expressed by hand or with a breast pump. Donors were instructed by nurses from the pediatric department or from the Human Milk Bank (in the case of external donors) on compliance with the rules of hygienic collection [27] (hands washed, all components of the breast pump cleaned and disinfected). Milk was collected into 250 mL sterilized glass bottles distributed by the Human Milk Bank. Donors could bring either native fresh milk cooled to +4°C–+10°C or frozen milk. Upon receipt, the nurses at the Human Milk Bank made a visual inspection of the integrity of the glass bottles and stoppers. In the case of frozen milk, the milk had to be visibly frozen. The nurses also checked donors’ documentation.

2.3. Pre-Pasteurization Risk Assessment and Input Microbiological Control

For fresh milk, an initial quantitative microbiological assessment was conducted before pasteurization. The microbiological assessment was a check for the presence of aerobic bacteria and fungi in the milk. All microbiological testing was performed in the Department of Clinical Microbiology at the University Hospital and Faculty of Medicine in Hradec Králové. The quantitative pre-pasteurization evaluation was done according to the European Pharmacopoeia (EPh) Chapter 2.6.12: Microbiological testing of non-sterile products and water by direct inoculation on agar [28]. Five-dilution rows (dilution 1:10) were prepared in sodium chloride solution based on an expected bioburden of 103–105 CFU/mL. Each dilution of milk was inoculated on Columbia agar (Oxoid Ltd., Hampshire, UK). All plates were placed in an incubator (Memmert GmbH + Co. KG, Schwabach, Germany) for 18–24 h in an ambient atmosphere at 35 °C ± 2 °C. The following day all isolates were identified using MALDI-TOF MS (Bruker Daltonics, Hamburg, Germany). The colony count was determined based on the growth of microbes in the final dilution.
We used European and Australian standards as the criteria for the pre-pasteurization discard of milk (Table 1) [26].

2.4. Processing and Post-Pasteurization Microbiological Evaluation

After testing, the milk was processed on the same day or after separate intermediate storage in a freezer (Liebherr GG 5210, Liebherr Hausgeräte, Ochsenhausen, Germany) operating from −25 °C to −27 °C. Bottles with fresh or frozen milk were put into a water bath of the warming section of the computer-assisted pasteurization equipment, where the milk was thawed and then pasteurized. The standard Holder pasteurization (62.5 °C for 30 min) followed by chilling was used as recommended by EMBA (European Milk Bank Association) standards [26]. For the warming phase, we used the BW-50 programmable water bath (ALFAMEDIC Ltd., Lišov, Czech Republic), in which the pasteurization process was regulated according to the temperature achieved inside a reference bottle containing a milk analog (Figure 1).
Immediately after pasteurization, the bottles were moved to a programmable chilling water bath (BW-50.1) of the same producer as mentioned above and the milk was chilled to +15 °C ± 0.5 °C. The temperature was again measured in a reference bottle, and chilling was automatically stopped at +15 °C. After chilling, the bottles were removed and placed into a laminar flow cabinet (Alpina Bio 130, Alpina, Konin, Poland). For qualitative microbiological evaluation, 1 mL of milk from each bottle was inoculated into 5 mL of thioglycollate broth (LMS, Ústí nad Labem, Czech Republic) (Figure 2).
The milk was divided into 100- or 50-mL sterile distribution bottles and sampling was performed (Figure 2). Then the bottles were rapidly frozen to −16 °C in a blast freezer (CZM 20/8V, Horákové Brothers, Lužec nad Vltavou, Czech Republic) (Figure 3).
The process takes 1–2 h, depending on the number of bottles in a pasteurization batch. The frozen bottles are removed and stored separately in a quarantine freezer. The temperature data for pasteurization, chilling and freezing for each batch were recorded by the system (Netcom and Read 95, Regucon, Ltd., Prague, Czech Republic) and stored in electronic and printed form. These records were reviewed by qualified person of the Human Milk Bank before the release of each batch for clinical use.
All equipment used for pasteurization, freezing and storage of human milk was regularly validated by Kalist, Ltd., Holešov, Czech Republic. The parameters of the environment in the Human Milk Bank premises, temperature and relative humidity were continuously monitored and recorded by the same system as mentioned above.
All vials with inoculated thioglycollate broth were incubated in the dark for 18–24 h in an ambient atmosphere at 35 °C ± 2 °C (at the Department of Clinical Microbiology) and then inoculated on Columbia agar (Oxoid, Ltd., Hampshire, UK). All plates were incubated again for 18–24 h in an ambient atmosphere at 35 °C ± 2 °C. The following day, colonies of microbes were found, and all isolates were identified using MALDI-TOF MS (Bruker Daltonics, Hamburg, Germany).
Only bottles with negative post-pasteurization microbiological results were released for clinical use and transferred to a dispensing freezer (Liebherr GG 5210, Liebherr Hausgeräte, Ochsenhausen, Germany) operating at a temperature from −25 °C to −27 °C). The shelf life of frozen milk stored at this temperature was three months. A schematic description of the manufacturing and control processes is presented in Figure 4.

2.5. Design of the Experiment

The design of the study is shown schematically in Figure 5, and a detailed description of the methodology is presented in Section 2.5.1, Section 2.5.2, Section 2.5.3 and Section 2.5.4

2.5.1. Analysis of the Presence of B. cereus in PBM

The first part of our study was based on a retrospective analysis of results of 30,943 tests performed during the four-year study period as a part of routine qualitative bacteriological control described in Section 2.4.

2.5.2. Seasonal Prevalence of B. cereus

To determine whether B. cereus in PBM would change significantly during the warmer months of the year, we compared its frequency in the cold and warm periods of the tested years. To compensate for considerable temperature deviations from the norm in the spring months of 2018 and 2019, we chose April to September as the warmer months and October to March as the colder months. Tables S1–S3 showing the mean daily temperatures in April, May, and September and deviations from the norm in the observed period reported by INFOMET [29], have been added as supplementary data. Categorical variables were compared using the Fisher exact test and presented as numbers (%). Differences were considered significant at p < 0.05. All p-values were obtained using two-tailed tests. All statistical analyses were performed using GraphPad Prism version 8.4.3.
In the second part of our investigations, two separate prospective studies were performed. In 20 samples originating from 20 donors, revealing a post-pasteurization B. cereus positivity quantitative evaluation was made as described in Part Section 2.5.3. In another 20 samples, the B. cereus strains were isolated and stored in a frozen state for enterotoxin production (diarrheal type) testing (Part Section 2.5.4).

2.5.3. Quantitative Post-Pasteurization Bacteriological Evaluation of B. cereus Positive Milk

Quantitative determination was carried out per European Pharmacopoeia (EPh) Chapter 2.6.12: Microbiological testing of non-sterile products and water by direct inoculation on agar [28]. 500 μL of PBM was inoculated directly on two Columbia agars (Oxoid), the agars were further incubated at an ambient atmosphere of 35 ± 2 °C. After 18–24 and 48 h count of CFU (colony forming unit) per mL for each milk sample and time was determined.

2.5.4. Enterotoxin Production Assessment

This prospective study collected B. cereus strains from pasteurized milk processed in 2020, one sample per donor. The strains were stored frozen in the cryobank at −70 °C ± 5 °C (I-TEST Plus, Hradec Králové, Czech Republic) and revitalized according to the manufacturer’s instructions. Enterotoxin production was determined using OxoidTM BCET-RPLA Toxin Detection Kit (Thermo Fisher Scientific, Waltham, Massachusetts, USA) in V-well microtiter plates. If B. cereus enterotoxins were present, agglutination occurred due to the formation of a lattice structure [30].

3. Results

3.1. Basic Characteristic of Human Milk Bank Donation and Processing Activities

The total amount of collected milk during the study period was 6815.71 L (30,943 bottles), with an average of 1703.93 L per year. There has been an increasing trend in the total amount of collected milk over the last four years (Table 2); most of the milk came from mothers hospitalized in the Pediatric department with their newborns.

3.2. Results of the Pre-Pasteurization (Input) Bacteriological Control

Table 3 shows the results of the pre-pasteurization (input) microbiological evaluation.

3.3. Results of Post-Pasteurization Control

During the study period, 30,943 tests were performed after pasteurization. Positive microbiological findings were detected in 2739 (8.85%) cases. Table 4 presents the total post-pasteurization PBM discard rate over the last four-year study. The data show a steady discard rate due to microbiological findings over the period.

The Spectrum of Bacterial Isolates

The spectrum of bacterial isolates is shown in Figure 6. Aerobic Gram-positive spore-forming bacteria dominated the positive post-pasteurization findings. The most common group was Gram-positive spore-forming rods (71.54%), including B. cereus (63.99%). The second most dangerous bacterium in milk, Staphylococcus aureus (Gram-positive cocci), was found in 30 tests, but only caused the elimination of only 1.10% PBM. No yeasts or molds were found.
The proportion of B. cereus is presented in Figure 7, as well as the relative frequency of individual strains surviving pasteurization in Table 5.

3.4. Assessment of the Seasonal Prevalence of B. cereus

The results shown in Table 6 indicate that the seasonal prevalence of B. cereus was confirmed in all monitored years. The prevalence of B. cereus in warm months was significantly higher than in the colder months of the same year. Figure 8 shows the frequency of positive B. cereus findings in individual months.

3.5. Results of the B. cereus Quantitative Post-Pasteurization Evaluation

The results are presented in Table 7. In 80% of cases, a quantity lower than 10 CFU/mL was found.

3.6. Results of the Enterotoxin Production Assessment

The production of diarrheal enterotoxin, assessed by reversed passive latex agglutination, was found in 3 of 20 (15.0%) B. cereus isolates from PBM.

4. Discussion

B. cereus survival in pasteurized milk is well established [2,31]; studies examining the frequency of positive B. cereus findings after Holder pasteurization, which is used by most Human Milk Banks and as recommended by EMBA, are only now starting to appear [18,19,20]. Simultaneously research into B. cereus toxigenicity has been intensified [20,32]. It has been caused by the fact that in the past, the main focus was S. aureus, enterococci, and coagulase-negative staphylococci in PBM [25], while detailed diagnostics of the genus Bacillus was not routinely performed. The positive findings remained hidden in the group evaluated as Bacillus sp. Using the MALDI method, Mullié et al. (2018) described the Bacillus genus as the leading cause of post-pasteurization non-compliance, followed by coagulase-negative Staphylococci. Recently Cormontagne et al. identified B. cereus as the leading cause of post-pasteurization PBM discard at Human Milk Banks using similar processing and control procedures as those described in this study [20]. The study of Cormontagne et al. also examined seasonal fluctuation of B. cereus prevalence and described a peak in the summer months.
Our study also found that B. cereus was a major cause of PBM discard (Figure 7); its proportion was, however, lower than reported by Cormontagne. Moreover we studied in detail the differences in the month-to-month prevalence of B. cereus positivity during the year (Figure 8, Table 6) and found a statistically significant increase in B. cereus prevalence in the warmer months (Table 6). In our case the warmer months included summer months, as well as spring months, i.e., April and May of the observational years, when temperatures were well above average for the Czech Republic (Tables S1–S3 in the supplementary data). Moreover, 2018 was the warmest year of the last 60 years, which was followed by 2019. This undoubtedly reflects the influence of climate changes and points to the need to implement the technical and organizational measures required for careful maintenance of the cold chain during the whole process of collection, transport, storage and distribution of PBM, including strict adherence to the instructions issued by Human Milk Banks regarding the proper use of PBM in pediatric wards.
Better diagnostics has led to an enlargement of the spectrum of microbes capable of surviving pasteurization (Figure 7, Table 5). In addition to the pathogenic or potentially pathogenic genera identified in our previous studies [25,33], Burkholderia, Kocuria, Moraxella, Roseomonas, Sphingomonas and Stenotrophomonas were identified in this study (Figure 7, Table 5). We encountered similar genera described by others who used the MALDI method [31], e.g., Moraxella spp., Stenotrophomonas spp., and Acinetobacter spp.
There is no consensus about the acceptable bacteriological contamination of PBM. While some standards permit contamination (all strains) lower than 10 CFU/mL (Italy, Sweden, UK), others do not tolerate any post-pasteurization contamination (France, Australia, USA) [26]. The post-pasteurization quantities of B. cereus CFU found in this study were within the 10 CFU/mL limit in most (80%) cases (Table 7). However, the current trend is not to permit any B. cereus contamination after pasteurization [20]; in which case only 20% of samples presented in Table 7 were B. cereus negative and/or had contamination below the detection limit. Together with the low prevalence of toxicogenic B. cereus isolates (15%), we regard this finding as good evidence of the efficiency of our current pasteurization process. On the other hand, occasional findings (5%) of 100 CFU/mL show that even when following EMBA recommendations for pasteurization and GMP principles, the routine post-pasteurization bacteriological controls we performed are fully justified to assure the safety of the product.
Our total PBM discard rate due to positive post-pasteurization findings fluctuated between 8.6% and 10.5% (Table 4) and was in the middle of the interval of the total discard rate found by Dewitte et al. in a survey performed in six major French Human Milk Banks (4–16%) [34]. It was also lower than the discard rate reported in a recent review by Cormontagne [20]. This might be caused by the fact that we perform a complete post-pasteurization control of each bottle, thereby eliminating the need to discard whole PBM batches that consist of large quantities of milk pooled from several human milk donors. Our technology also makes it possible to trace milk from donors to premature newborns fed with PBM products; we regard traceability as an important principle of our Quality Assurance System. This aspect of safety assurance was pointed out also by Fournier et al. [24].
Another cause of our relatively low PBM discard rate might be the fact that in our practice the majority of collected milk is frozen immediately after collection. The results of input microbiological control performed in the rare cases when milk is referred to the bank in the liquid state (Table 3) reveal good compliance with the generally accepted limits (Table 1). Our results show the importance of careful analyses of the prevalence of different bacteriological strains that show higher resistance to the pasteurization process as a part of the implementation of the HACCP system, which is an important part of the Quality Management System recommended by EMBA [26]. The spectrum of strains presented in this study may be hospital and/or pediatric department-specific and may change over time; nevertheless, similar spectra of surviving microbes have been reported also by other authors [2,31].
It is clear that when using standard Holder pasteurization, bacterial spores of bacteria are capable of surviving the pasteurization process, meaning that any further lowering of the PBM discard rate may not be possible. Changing technology to the innovative pasteurization procedures recently described [20,22] might improve discard rates, it would require a long period of experimental verification. High-pressure inactivation, which Demazeau described as being effective against spores [23], is regarded by us to be a promising method for the future; as our group also found the technique effective on bacteria present in human and cow milk in the past [33,35].
In our system, all PBM is distributed in the frozen state which eliminates the possibility of growth of vegetative B. cereus forms surviving pasteurization, which can occur if PBM is stored at refrigeration temperatures [8]. Since pasteurization impairs the natural antibacterial properties of human milk [36], it creates conditions suitable for the multiplication of microbes that can be more rapid than in case of storage of liquid raw human milk above zero degrees. Moreover, B. cereus is capable of growing even at temperatures near zero. These characteristics of B. cereus must be considered during risk assessment of cold storage of PBM as well as storage and use of PMB on the pediatric wards. There are growth models available for many microbes surviving pasteurization [25,35,37], which are suitable tools for properly assessing this risk.

5. Conclusions

In Human Milk Banks using the standard Holder pasteurization process, B. cereus may substantially contribute to the rate of PBM discard performed based on the post-pasteurization bacteriological control. In this study, B. cereus was the leading cause of PBM discard, and the discard rate significantly increased during the warmer months of the year (April to September). B. cereus PBM CFU-quantities described in this study were mostly below 10 CFU/mL; nevertheless, occasional findings of higher quantities fully justified the routine post-pasteurization bacteriological control as recommended by the EMBA. Post-pasteurization survivability of B. cereus must be taken into account when assessing the risk of cold storage of PBM at temperatures above zero and when assessing the risk of storage and use of PBM in the pediatric wards prior to administration to newborns.
Regular evaluations of the spectrum of strains surviving pasteurization, including B. cereus, and monitoring changes and trends should be a part of the Quality Management System of Human Milk Banks.
The post-pasteurization discard rate of 8.23–10.0% described in this study is acceptable and lower than reported from other Human Milk Banks using similar processing and control methods. According to the authors´ opinions, further lowering of discard rates is scarcely possible without changes in decontamination technologies. The authors regard high-pressure inactivation to be a promising method for the future.

Supplementary Materials

The following are available online at https://0-www-mdpi-com.brum.beds.ac.uk/article/10.3390/foods10122955/s1, Table S1: Temperatures in April, Klementinum, Prague, Table S2: Temperatures in May 2017–2020, Klementinum, Prague, Table S3: Temperatures in September 2017–2020, Klementinum, Prague.

Author Contributions

M.J.; investigation, writing—original draft, P.M.; writing—review & editing, M.F.; data curation, A.L.; methodology; P.P.; methodology, L.H.; supervision, E.J.; data curation, M.K.; formal analysis, M.H.; writing—review & editing. All authors have read and agreed to the published version of the manuscript.

Funding

This project was supported by MH CZ–DRO (UHHK, 00179906), and grant projects SVV 260543/2020 and PROGRES Q40/06 from Charles University. The research was also supported by the Ministry of Agriculture of the Czech Republic (institutional support MZE-RO0318).

Institutional Review Board Statement

The study was approved by the Ethics Committee of the University Hospital Hradec Kralove, the approval number from the Ethics Committee is No. 201911I70P.

Informed Consent Statement

Subjects in the study have given written informed consent.

Data Availability Statement

Not applicable.

Acknowledgments

Authors would like to thank to all subjects that have supported this study, especially the Ministry of Agriculture of the Czech Republic (institutional support MZE-RO0318), the University Hospital Hradec Králové (UHHK, 00179906), and Faculty of Medicine Hradec Králové, Charles University (grant projects SVV 260543/2020 and PROGRES Q40/06).

Conflicts of Interest

We confirm that this work is original and has not been published elsewhere, nor is it currently under consideration for publication elsewhere. We have no conflict of interest to disclose.

References

  1. Hilliard, N.J.; Schelonka, R.L.; Waites, K.B. Bacillus cereus bacteremia in preterm neonate. J. Clin. Microbiol. 2003, 41, 3441–3444. [Google Scholar] [CrossRef] [PubMed] [Green Version]
  2. Decousser, J.W.; Ramarao, N.; Duport, C.; Dorval, M.; Bourgeois-Nicolaos, N.; Guinebretière, M.H.; Razafimahefa, H.; Doucet-Populaire, F. Bacillus cereus and severe intestinal infections in preterm neonates. Putative role of pooled breast milk. Am. J. Infect. Control. 2013, 41, 918–921. [Google Scholar] [CrossRef] [PubMed]
  3. Ministry for Primary Industries. Risk Profile: Bacillus Cereus in Dairy Products. MPI Technical Paper No. 2016/58. Available online: http://www.mpi.govt.nz/news-and-recources/publications/ (accessed on 11 November 2021).
  4. International Dairy Federation. Bacillus Cereus in Milk and Dairy Products. IDF Factsheet-December 2016. Available online: https://www.fil-idf.org (accessed on 11 November 2021).
  5. Vidic, J.; Chaix, C.; Manzano, M.; Heyndrickx, M. Food Sensing: Detection of Bacillus cereus Spores in Dairy Products. Biosensors 2020, 25, 15. [Google Scholar] [CrossRef] [Green Version]
  6. Stenfors Arnesen, L.P.; Fagerlund, A.; Granum, P.E. From soil to gut: Bacillus cereus and its food poisoning toxins. FEMS Microbiol. Rev. 2008, 32, 579–606. [Google Scholar] [CrossRef] [PubMed] [Green Version]
  7. Rocha-Pimienta, J.; Martillanes, S.; Ramirez, R.; Parra, J.G.; Delgado, J. Bacillus cereus spores and Staphylococcus aureus sub. Aureus vegetative cell´s inactivation in human milk by high-pressure processing. Food Control 2020, 113, 107212. [Google Scholar] [CrossRef]
  8. Proroga, Y.T.R.; Capuano, F.; Castellano, S.; Giordano, A.; Mansuci, A.; Delibato, E.; Dumontet, S.; Pasqual, V. Occurrence and toxin gene profile of Bacillus cereus in dairy products. J. Microbiol. Biotechnol. Food Sci. 2019, 9, 58–62. [Google Scholar] [CrossRef]
  9. Ramarao, N.; Belotti, L.; Deboscker, S.; Ennahar-Vuillemin, M.; de Launay, J.; Lavigne, T.; Koebel, C.; Escande, B.; Guinebretière, M.H. Two unrelated episodes of Bacillus cereus bacteremia in a neonatal intensive care unit. Am. J. Infect. Control 2014, 42, 694–695. [Google Scholar] [CrossRef] [PubMed]
  10. Demers-Mathieu, V.; Mathijssen, G.; Fels, S.; Chace, D.H.; Medo, E. Impact of vaccination during pregnancy and staphylococci concentration on the presence of Bacillus cereus in raw human milk. J. Perinatol. 2020, 40, 1323–1330. [Google Scholar] [CrossRef]
  11. Manickam, N.; Knorr, A.; Muldrew, K.L. Neonatal meningoencephalitis caused by Bacillus cereus. Pediatr. Infect. Dis. J. 2008, 27, 843–846. [Google Scholar] [CrossRef]
  12. Frankard, J.; Li, R.; Taccone, F.; Struelens, M.J.; Jacobs, F.; Kentos, A. Bacillus cereus pneumonia in a patient with acute lymphoblastic leukemia. Eur. J. Clin. Microbiol. Infect. Dis. 2004, 23, 725–728. [Google Scholar] [CrossRef]
  13. Lequin, M.H.; Vermeulen, J.R.; van Elburg, R.M.; Barkhof, F.; Kornelisse, R.F.; Swarte, R.; Govaert, P.P. Bacillus cereus meningoencephalitis in preterm infants: Neuroimaging characteristics. AJNR Am. J. Neuroradiol. 2005, 26, 2137–2143. [Google Scholar]
  14. Wiedermann, B.L. Non-anthrax Bacillus infections in children. Pediatr. Infect. Dis. J. 1987, 6, 218–220. [Google Scholar]
  15. France info. Le Lactarium d’Ile-de-France Suspend la Distribution de Lait Maternel Issu Dedons, Après la Mort Suspecte de Deux Nourrissons. Available online: http://www.francetvinfo.fr/sante/enfant-ado/lactarium-de-necker-aucune-preuve-de-contamination-du-lait-a-ce-stade_1810531.html (accessed on 19 January 2017).
  16. Lewin, A.; Quach, C.; Rigourd, V.; Picaud, J.C.; Perreault, T.; Frange, P.; Domingo, M.C.; Lalancette, C.; Delage, G.; Germain, M. Bacillus cereus infection in neonates and the absence of evidence for the role of banked human milk: Case reports and literature review. Infect. Control. Hosp. Epidemiol. 2019, 40, 787–793. [Google Scholar] [CrossRef]
  17. Guinebretiere, M.H.; Nguyen-The, C. Sources of Bacillus cereus contamination in a pasteurized zucchini purée processing line, differentiated by two PCR-based methods. FEMS Microbiol. Ecol. 2003, 43, 207–215. [Google Scholar] [CrossRef]
  18. Sarita Kumari, P.K.S. Bacillus cereus hazard and control in industrial dairy processing environment. Food Control 2016, 69, 20–29. [Google Scholar] [CrossRef]
  19. Glasset, B.; Herbin, S.; Granier, S.A.; Cavalié, L.; Lafeuille, E.; Guérin, C.; Ruimy, R.; Casagrande-Magne, F.; Levast, M.; Chautemps, M.; et al. Bacillus cereus, a serious cause of nosocomial infections: Epidemiologic and genetic survey. PLoS ONE 2018, 13, e0194346. [Google Scholar]
  20. Cormontagne, D.; Rigourd, V.; Vidic, J.; Rizzotto, F.; Bille, E.; Ramarao, N. Bacillus cereus Induces Infections in Preterm Neonates: Implication at the Hospital and Human Milk Bank Level. Toxins 2021, 13, 123. [Google Scholar] [CrossRef]
  21. Lima, H.K.; Wagner-Gillespie, M.; Perrin, M.T.; Fogleman, A.D. Bacteria and Bioactivity in Holder Pasteurized and Shelf-Stable Human Milk Products. Curr. Dev. Nutr. 2017, 1, e001438. [Google Scholar] [CrossRef]
  22. Wesolowska, A.; Sinkiewicz-Darol, E.; Barbarska, O.; Bernatowicz-Lojko, U.; Borszewska-Kornacka, M.K.; van Goudoever, J.B. Innovative Techniques of Processing Human Milk to Preserve Key Components. Nutrients 2019, 11, 1169. [Google Scholar] [CrossRef] [Green Version]
  23. Demazeau, G.; Plumecocq, A.; Lehours, P.; Martin, P.; Couëdelo, L.; Billeaud, C. A New High Hydrostatic Pressure Process to Assure the Microbial Safety of Human Milk While Preserving the Biological Activity of Its Main Components. Front. Public Health. 2018, 6, 306. [Google Scholar] [CrossRef]
  24. Fournier, S.; Faraut-Derouin, V.; Casetta, A.; Frange, P.; Doit, C.; Fortineau, N.; Romain, O.; Patkai, J.; Chillaz, C.; Rigourd, V.; et al. Bactériémies à Bacillus cereus en réanimation néonatale à l’AP-HP en 2016. Bull. Epidémiol. Hebd. BEH 2018, 25, 536–540. [Google Scholar]
  25. Měřička, P.; Houska, M.; Landfeld, A.; Čermák, M. Quantitative assessment of microbiological risk in processing and application of the pasteurized frozen human milk. In Proceedings of the ICR2003, IIR/IIF, International Congress of Refrigeration, Washington, DC, USA, 17–22 August 2003. paper No. ICR0645. [Google Scholar]
  26. Weaver, G.; Bertino, E.; Gebauer, C.; Grovslien, A.; Mileusnic-Milenovic, R.; Arslanoglu, S.; Barnett, D.; Boquien, C.Y.; Buffin, R.; Gaya, A.; et al. Recommendations for the Establishment and Operation of Human Milk Banks in Europe: A Consensus Statement from the European Milk Bank Association (EMBA). Front. Pediatr. 2019, 7, 53. [Google Scholar] [CrossRef] [PubMed]
  27. Council of Europe. The Guide to the Quality and Safety of Organs for Transplantation, 4th ed.; European Directorate for the Quality of Medicines & HealthCare (EDQM): Strasbourg, France, 2019; pp. 327–332. [Google Scholar]
  28. The European Pharmacopoeia (Ph. Eur.) 6.0. 2612 Microbiological Testing of Non-Sterile Products and Water by Direct Inoculation on Agar; Council of Europe: Strasbourg, France, 2008; pp. 4398–4404. [Google Scholar]
  29. INFOMET. Information Web of the ČHMÚ (Czech Hydrometeorological Institute-Governmental Agency). Available online: http://www.infomet.cz/ (accessed on 11 November 2021).
  30. Thermo Fisher Scientific. BCET RPLA Toxin Detection Kit. Available online: http://www.oxoid.com/uk/blue/prod_detail/prod_detail.asp?pr=TD0950&org=9&c=uk&lang=en (accessed on 3 October 2020).
  31. Mullie, C.; Obin, O.; Outurquin, G.; Grognet, S.; Léké, A.; Adjidé, C. Breast milk donations: Bacteriological assessment, analysis of causes of non-compliance and suggestions for improvement. Arch. Pediatr. 2018, 25, 263–268. [Google Scholar] [CrossRef] [PubMed]
  32. Saleh-Lakha, S.; Leon-Velarde, C.G.; Chen, S.; Lee, S.; Shannon, K.; Fabri, M.; Downing, G.; Keown, B. A Study To Assess the Numbers and Prevalence of Bacillus cereus and Its Toxins in Pasteurized Fluid Milk. J. Food Prot. 2017, 80, 1085–1089. [Google Scholar] [CrossRef] [PubMed]
  33. Landfeld, A.; Strohalm, J.; Kýhos, K.; Průchová, J.; Houška, M.; Novotná, P.; Schlemmerová, L.; Šmuhařová, H.; Špelina, V.; Čermák, P.; et al. High pressure inactivation of Enterococcus faecium—Modelling and verification. Czech J. Food Sci. 2009, 27, 134–141. [Google Scholar] [CrossRef] [Green Version]
  34. Dewitte, C.; Courdent, P.; Chartier, C.; Dumoulin, D.; Courcol, R.; Pierrat, V. Contamination du lait maternel par une flore aériobie: Évaluation des pertes pour un lactarium. Arch. Pediatr. 2015, 22, 461–467. [Google Scholar] [CrossRef]
  35. Schlemmerová, L.; Houška, M.; Špelina, V.; Strohalm, J.; Landfeld, A.; Měřička, P. Baroinactivation of Staphylococcus epidermidis–mathematical model and its verification using human and cow milk. Czech J. Food Sci. 2009, 27, 118–126. [Google Scholar] [CrossRef] [Green Version]
  36. Gaya, A.; Calvo, J. Improving pasteurization to preserve the biological components of donated human milk. Front. Pediatr. 2018, 6, 288. [Google Scholar] [CrossRef]
  37. Čermák, P.; Landfeld, A.; Měřička, P.; Houška, M. Enterococcus faecium growth Model. Czech J. Food Sci. 2009, 27, 361–371. [Google Scholar] [CrossRef] [Green Version]
Figure 1. Bottles with collected milk in the warming section of the pasteurization device. The temperature is monitored and recorded inside the water bath and in the bottle containing the milk analog.
Figure 1. Bottles with collected milk in the warming section of the pasteurization device. The temperature is monitored and recorded inside the water bath and in the bottle containing the milk analog.
Foods 10 02955 g001
Figure 2. Collection of the milk samples for qualitative bacteriological analysis.
Figure 2. Collection of the milk samples for qualitative bacteriological analysis.
Foods 10 02955 g002
Figure 3. Distribution bottles in the blast freezer. The temperature of the air and inside the bottle containing the milk analog is recorded.
Figure 3. Distribution bottles in the blast freezer. The temperature of the air and inside the bottle containing the milk analog is recorded.
Foods 10 02955 g003
Figure 4. Diagram of the manufacturing and control processes.
Figure 4. Diagram of the manufacturing and control processes.
Foods 10 02955 g004
Figure 5. The design of the study.
Figure 5. The design of the study.
Foods 10 02955 g005
Figure 6. Frequency [%] of microbial groups in PBM (2017–2020).
Figure 6. Frequency [%] of microbial groups in PBM (2017–2020).
Foods 10 02955 g006
Figure 7. Post-pasteurization contamination shows percentage contamination by individual strains.
Figure 7. Post-pasteurization contamination shows percentage contamination by individual strains.
Foods 10 02955 g007
Figure 8. The frequency of positive B. cereus findings in individual months.
Figure 8. The frequency of positive B. cereus findings in individual months.
Foods 10 02955 g008
Table 1. Criteria for the pre-pasteurization discard of milk.
Table 1. Criteria for the pre-pasteurization discard of milk.
StandardsExclusion Criteria
French legislationTotal bacteria ≥ 105 CFU/mL
Italian guidelinesStaphylococcus aureus > 104 CFU/mL
French legislationStaphylococcus coagulase-positive ≥ 104 CFU/mL
Australian guidelinesAny enterobacteriaceae, enterococci, or potential pathogens capable of producing heat-stable enterotoxins
Table 2. The total amount of collected milk and the sources, i.e., external or hospitalized donors.
Table 2. The total amount of collected milk and the sources, i.e., external or hospitalized donors.
YearTotal Amount of Collected Milk (L)Milk from External Donors [%]Milk from Hospitalized Donors [%]
20171630.0516.6883.32
20181454.656.3593.65
20191597.3014.4585.55
20202133.7136.9063.10
Table 3. Results of the input microbiological evaluation.
Table 3. Results of the input microbiological evaluation.
YearTotal Number of Input TestsTotal Bacteria ≥ 105 CFU/mLStaphylococcus aureus > 104 CFU/mL
20171110
20182901
20192200
20201001
Table 4. Percentage of discarded PBM due to input and post-pasteurization positive microbial findings.
Table 4. Percentage of discarded PBM due to input and post-pasteurization positive microbial findings.
YearInput Control [%] Post-Pasteurization Control [%]Total [%]
20170.288.628.90
20180.438.238.66
20190.0010.0010.00
20200.109.279.37
Table 5. Results of post-pasteurization microbiological evaluation—the relative frequency of individual strains.
Table 5. Results of post-pasteurization microbiological evaluation—the relative frequency of individual strains.
Genus(%)Genus(%)
Acinetobacter0.71Leuconostoc0.04
Aerococcus0.12Micrococcus0.94
Bacillus70.63Moraxella2.71
Brevibacillus0.08Paenibacillus0.75
Brevibacterium0.04Pantoea0.04
Burkholderia0.04Pseudomonas0.08
Corynebacterium0.35Rhizobacterium0.04
Enterococcus5.94Roseomonas0.04
Staphylococcus (coagulase-negative)13.65Sphingomonas0.04
Staphylococcus (coagulase-positive)1.18Stenotrophomonas0.12
Kocuria0.08Streptococcus (α-hemolytic species)2.32
Lactobacillus0.08
Table 6. Seasonal prevalence of B. cereus.
Table 6. Seasonal prevalence of B. cereus.
Prevalence (%)
YearPeriodB. cereusOther Microbesp Value
2017April–September6044p < 0.0001
October–March4056
2018April–September7153p < 0.0001
October–March2947
2019April–September7560p < 0.0001
October–March2540
2020April–September6855p = 0.0004
October–March3245
Table 7. Results of the quantitative B. cereus post-pasteurization evaluation.
Table 7. Results of the quantitative B. cereus post-pasteurization evaluation.
CFU/mL RangeFrequencyRelative Frequency (%)Cumulative Relative Frequency (%)
Negative42020
1–5105070
6–1021080
11–151585
16–200085
21–251590
26–300090
31–350090
36–400090
41–450090
46–500090
51–991595
10015100
Total20xxxxxx
Publisher’s Note: MDPI stays neutral with regard to jurisdictional claims in published maps and institutional affiliations.

Share and Cite

MDPI and ACS Style

Jandová, M.; Měřička, P.; Fišerová, M.; Landfeld, A.; Paterová, P.; Hobzová, L.; Jarkovská, E.; Kacerovský, M.; Houška, M. Bacillus cereus as a Major Cause of Discarded Pasteurized Human Banked Milk: A Single Human Milk Bank Experience. Foods 2021, 10, 2955. https://0-doi-org.brum.beds.ac.uk/10.3390/foods10122955

AMA Style

Jandová M, Měřička P, Fišerová M, Landfeld A, Paterová P, Hobzová L, Jarkovská E, Kacerovský M, Houška M. Bacillus cereus as a Major Cause of Discarded Pasteurized Human Banked Milk: A Single Human Milk Bank Experience. Foods. 2021; 10(12):2955. https://0-doi-org.brum.beds.ac.uk/10.3390/foods10122955

Chicago/Turabian Style

Jandová, Miroslava, Pavel Měřička, Michaela Fišerová, Aleš Landfeld, Pavla Paterová, Lenka Hobzová, Eva Jarkovská, Marian Kacerovský, and Milan Houška. 2021. "Bacillus cereus as a Major Cause of Discarded Pasteurized Human Banked Milk: A Single Human Milk Bank Experience" Foods 10, no. 12: 2955. https://0-doi-org.brum.beds.ac.uk/10.3390/foods10122955

Note that from the first issue of 2016, this journal uses article numbers instead of page numbers. See further details here.

Article Metrics

Back to TopTop